F.A.S.T. of The Alleghenys

                                                                                                           Date: ______________

Fire Department ________________________Truck # __________ Mileage ___________ Chassis Year ________

Chassis Make/Model ________________________________________ VIN________________________________

Pump Make/Model _______________________________ Pump S/N _________________ Pump Hr Meter _______

                        Pump                                                             Body/Chassis

 N/A OK                                                                                                N/A OK

___    ___ Grease impeller shaft bearings (Waterous)                           ___   ___ Check for body rubber movement

___     ___ Clean sump strainer & breather (Waterous)                        ___   ___ Grease steering components

___     ___ Check auto lube (Hale)                                                          ___   ___ Check rear axle oil level

___     ___ Change pump oil                                                                   ___   ___ Check & tighten U-Bolts

___     ___ Evaluate pump oil                                                                 ___   ___ Grease & inspect drive lines

___     ___ Check anodes                                                                        ___    ___ Check auto tire chains operation

___     ___ Check primer fluid                                                                 ___   ___ Check for air leaks

___     ___ Lubricate internal air shift components                                ___   ___ Check body for stress fractures

___     ___ Clean/Inspect relief valve strainer

___     ___ Check relief valve or governor operation

___     ___ Inspect packing drip rate, adjust if needed                                         Electrical

___     ___ Check pump gauges, tach, panel lights, etc.                          N/A OK              

___    ___ Lubricate valve linkages                                                        ___     ___ Check all ICC lights

___     ___ Clean & lubricate master drains                                           ___    ___ Check all emergency lights

___     ___ Lubricate panel discharge drains                                         ___    ___ Check siren & Q

___     ___ Inspect plumbing                                                                   ___    ___ Run generator & check outlets

___     ___ *Perform vacuum test: Pulled -_____ in. Hg.                        ___    ___ Lubricate door ajar switches

(Vacuum dropped to -______in. Hg. In 5 min.)                                      ___    ___ Check interlocks on tank/ladder rack

N/A OK

___    ___ Check grab handles for looseness

___    ___ Check/adjust compartment door latches

___    ___ Check air horn operation

___    ___ Check A/C & heater operation (Rescue Only)

___    ___ Check pump intake screens                            * Suctions and discharges are capped off during vacuum test.

___    ___ Inspect and grease suction gaskets

Notes: